EI、Scopus 收录
中文核心期刊
Yue Shuwen, Du Wangfang, Li Kai, Zhao Jianfu. Numerical study on flashing front propagation phenomenon in vertical tube. Chinese Journal of Theoretical and Applied Mechanics, 2023, 55(8): 1627-1636. DOI: 10.6052/0459-1879-23-115
Citation: Yue Shuwen, Du Wangfang, Li Kai, Zhao Jianfu. Numerical study on flashing front propagation phenomenon in vertical tube. Chinese Journal of Theoretical and Applied Mechanics, 2023, 55(8): 1627-1636. DOI: 10.6052/0459-1879-23-115

NUMERICAL STUDY ON FLASHING FRONT PROPAGATION PHENOMENON IN VERTICAL TUBE

  • Received Date: March 29, 2023
  • Accepted Date: June 08, 2023
  • Available Online: June 09, 2023
  • The flashing front propagation phenomenon is a special kind of flashing phenomenon, which widely exists in the liquid discharge process of spacecraft in vacuum environment. The in-depth study of flashing front propagation is an important prerequisite for improving the research of flashing mechanism, predicting the liquid discharge process in vacuum, and promoting the controllability and safety of space activities. At present, the study of flashing front propagation phenomenon relies on experimental observation and lacks practical numerical methods. In order to avoid the huge amount of calculation brought by the cross-scale simulation, the calculation domain is divided into different regions, and an interfacial area concentration model is established in each region, thus realizing the two-dimensional numerical simulation of flashing front propagation under a single working condition. On this basis, this paper also proposes a modified gas-phase Weber number model for flashing front interfacial area concentration. This model characterizes the micromorphology of the interface under different temperature and pressure conditions, so that the numerical simulation can calculate and predict the superficial velocity of flashing front propagation under different temperature and pressure conditions. Finally, this paper simulates the cases under constant outlet pressure and different nominal superheat, and the cases under constant superheat and different outlet pressure. The results show that when the outlet pressure keeps constant, both the real superheat at flashing front and the superficial velocity of flashing front propagation increases with the increase of the nominal superheat. And under low superheat, both real superheat and nominal superheat are approximately linear with the superficial velocity of flashing front. For cases under constant nominal superheat, the superficial propagation velocity is positively correlated with the outlet pressure.
  • [1]
    Maria ARM, Kalidasa MK, Rajaseenivasan T, et al. A review on flash evaporation desalination. Desalination and Water Treatment, 2015, 57(29): 13462-13471
    [2]
    Senda J, Wada Y, Kawano D, et al. Improvement of combustion and emissions in diesel engines by means of enhanced mixture formation based on flash boiling of mixed fuel. International Journal of Engine Research, 2008, 9(1): 15-27 doi: 10.1243/14680874JER02007
    [3]
    Cheng WL, Zhang WW, Chen H, et al. Spray cooling and flash evaporation cooling: the current development and application. Renewable and Sustainable Energy Reviews, 2016, 55: 614-628 doi: 10.1016/j.rser.2015.11.014
    [4]
    Reinke P. Surface boiling of superheated liquid. [PhD Thesis]. Villigen: Paul Scherrer Institute, 1997
    [5]
    Casal J. Evaluation of the Effects and Consequences of Major Accidents in Industrial Plants. Amsterdam: Elsevier, 2008
    [6]
    王德伟, 徐侃, 宁献文等. 高真空低重力环境下液态工质排放地面模拟试验研究. 航天器环境工程, 2019, 36(3): 257-263 (Wang Dewei, Xu Kan, Ning Xianwen, et al. Ground simulation test for the working fluid evacuation in high vacuum and low gravity environment. Spacecraft Environment Engineering, 2019, 36(3): 257-263 (in Chinese)

    Wang DW, Xu K, Ning XW, et al. Ground simulation test for the working fluid evacuation in high vacuum and low gravity environment. Spacecraft Environment Engineering, 2019, 36(3): 257–263 (in Chinese)
    [7]
    Grolmes MA, Fauske HK. Axial propagation of free surface boiling into superheated liquids in vertical tubes//5th International Heat Transfer Conference, Tokyo, Japan, 1974
    [8]
    Das PK, Bhat GS, Arakeri VH. Investigations on the propagation of free surface boiling in a vertical superheated liquid column. International Journal of Heat and Mass Transfer, 1987, 30(4): 631-638 doi: 10.1016/0017-9310(87)90193-1
    [9]
    Frost D, Sturtevant B. Effects of ambient pressure on the instability of a liquid boiling explosively at the superheat limit. Journal of Heat Transfer, 1986, 108(2): 418-424 doi: 10.1115/1.3246940
    [10]
    Hill LG, Sturtevant B. An experimental study of evaporation waves in adiabatic flashing//Transient Phenomena in Multiphase and Multicomponent Systems, Gottingen, Germany, 1990
    [11]
    Simões-Moreira JR, Shepherd JE. Evaporation waves in superheated dodecane. Journal of Fluid Mechanics, 1999, 382: 63-86 doi: 10.1017/S0022112098003796
    [12]
    Hahne E, Barthau G. Evaporation waves in flashing processes. International Journal of Multiphase Flow, 2000, 26(4): 531-547 doi: 10.1016/S0301-9322(99)00031-2
    [13]
    Reinke P, Yadigaroglu G. Explosive vaporization of superheated liquids by boiling fronts. International Journal of Multiphase Flow, 2001, 27(9): 1487-1516 doi: 10.1016/S0301-9322(01)00023-4
    [14]
    Kuznetsov VV, Kozulin IA, Vitovsky OV. Experimental investigation of adiabatic evaporation waves in superheated refrigerants. Journal of Engineering Thermophysics, 2012, 21(2): 136-143 doi: 10.1134/S1810232812020051
    [15]
    Dewangan KK, Das PK. Experimental analysis of flashing front propagation in superheated water-effects of degree of superheat, tube inclination, and secondary nucleation. Physics of Fluids, 2020, 32(7): 073311 doi: 10.1063/5.0006840
    [16]
    Yue SW, Du WF, Li K, et al. Experimental study on flashing front propagation in vertical small tubes. Experimental Thermal and Fluid Science, 2023, in press. https://doi.org/10.1016/j.expthermflusci.2023.110999
    [17]
    Hill LG. An experimental study of evaporation waves in a superheated liquid. [PhD Thesis]. California: California Institute of Technology, 1991
    [18]
    Harris LD. An analysis of the propagation mechanism for rapid evaporation waves. [PhD Thesis]. Toronto: University of Toronto, 2006
    [19]
    Mesler R, Mailen G. Nucleate boiling in thin liquid films. AIChE Journal, 1977, 23(6): 954-957 doi: 10.1002/aic.690230629
    [20]
    Blanchard DC, Woodcock AH. Bubble formation and modification in the sea and its meteorological significance. Tellus, 1957, 9(2): 145-158 doi: 10.3402/tellusa.v9i2.9094
    [21]
    Pumphrey HC, Elmore PA. The entrainment of bubbles by drop impacts. Journal of Fluid Mechanics, 1990, 220: 539-567 doi: 10.1017/S0022112090003378
    [22]
    Bird JC, De Ruiter R, Courbin L, et al. Daughter bubble cascades produced by folding of ruptured thin films. Nature, 2010, 465(7299): 759-762 doi: 10.1038/nature09069
    [23]
    Liao Y, Lucas D. A review on numerical modelling of flashing flow with application to nuclear safety analysis. Applied Thermal Engineering, 2021, 182: 116002 doi: 10.1016/j.applthermaleng.2020.116002
    [24]
    Karathanassis IK, Koukouvinis P, Gavaises M. Comparative evaluation of phase-change mechanisms for the prediction of flashing flows. International Journal of Multiphase Flow, 2017, 95: 257-270 doi: 10.1016/j.ijmultiphaseflow.2017.06.006
    [25]
    Saurel R, Pantano C. Diffuse-interface capturing methods for compressible two-phase flows. Annual Review of Fluid Mechanics, 2018, 50: 105-130 doi: 10.1146/annurev-fluid-122316-050109
    [26]
    Zein A, Hantke M, Warnecke G. Modeling phase transition for compressible two-phase flows applied to metastable liquids. Journal of Computational Physics, 2010, 229(8): 2964-2998 doi: 10.1016/j.jcp.2009.12.026
    [27]
    Dewangan KK, Das PK. Numerical simulation of flash evaporation in the presence of secondary nucleation. International Journal of Multiphase Flow, 2021, 142: 103703 doi: 10.1016/j.ijmultiphaseflow.2021.103703
    [28]
    Graña-Otero JC, Parra IE. Experimental results on evaporation waves. Defect and Diffusion Forum, 2011, 312-315: 635-640
    [29]
    Ansys Fluent Theory Guide. USA: ANSYS Inc., 2021
    [30]
    Cleary V, Bowen P, Witlox H. Flashing liquid jets and two-phase droplet dispersion. I. Experiments for derivation of droplet atomisation correlations. Journal of Hazardous Materials, 2007, 142(3): 786-796
    [31]
    Berna C, Escrivá A, Muñoz-Cobo JL, et al. Review of droplet entrainment in annular flow: Characterization of the entrained droplets. Progress in Nuclear Energy, 2015, 79: 64-86 doi: 10.1016/j.pnucene.2014.11.011
    [32]
    卢翔, 靳朝阳, 葛冰等. 平面液膜破碎及雾化过程的试验研究. 推进技术, 2022, 43(11): 1-9 (Lu Xiang, Jin Zhaoyang, Ge Bing, et al. Experiment research on break-up and atomization process of planar prefilm. Journal of Propulsion Technology, 2022, 43(11): 1-9 (in Chinese)

    Lu X, Jin ZY, Ge B, et al. Experiment research on break-up and atomization process of planar prefilm. Journal of Propulsion Technology, 2022, 43(11): 1–9 (in Chinese)
  • Related Articles

    [1]Liu Renhuai, Xue Jianghong. DEVELOPMENT OF NONLINEAR MECHANICS FOR LAMINATED COMPOSITE PLATES AND SHELLS[J]. Chinese Journal of Theoretical and Applied Mechanics, 2017, 49(3): 487-506. DOI: 10.6052/0459-1879-16-253
    [2]Chen Jianlin, Li Zheng, Chu Pengcheng. STRENGTH ANALYSIS OF FIBER REINFORCED COMPOSITE LAMINATES WITH BIG CUTOUTS[J]. Chinese Journal of Theoretical and Applied Mechanics, 2016, 48(6): 1326-1333. DOI: 10.6052/0459-1879-16-169
    [3]Li Nian, Chen Puhui. CONTINUUM DAMAGE MECHANICS MODEL FOR LOW-VELOCITY IMPACT DAMAGE ANALYSIS OF COMPOSITE LAMINATES[J]. Chinese Journal of Theoretical and Applied Mechanics, 2015, 47(3): 458-470. DOI: 10.6052/0459-1879-14-169
    [4]Wu Yitao, Yao Weixing, Wu Fuqiang. CDM MODEL FOR INTRALAMINAR PROGRESSIVE DAMAGE ANALYSIS OF COMPOSITE LAMINATES[J]. Chinese Journal of Theoretical and Applied Mechanics, 2014, 46(1): 94-104. DOI: 10.6052/0459-1879-13-106
    [5]Li Hongying, Guo Xinghui, Wang Yanqing, Li Jian, Xie Liyang, Chen Bo. ANALYSIS OF 1:3 INTERNAL RESONANCES FOR UNILATERAL PLATES PARTIALLY IMMERSED IN FLUID AND MOVING IN AXIAL DIRECTION[J]. Chinese Journal of Theoretical and Applied Mechanics, 2012, (3): 643-647. DOI: 10.6052/0459-1879-2012-3-20120323
    [6]Xiaoquan Cheng, Kun Yang, Renwei Hu, Jian Zou. Tensile fatigue damage and its mechanism of stitched composite laminates[J]. Chinese Journal of Theoretical and Applied Mechanics, 2010, 42(1): 132-137. DOI: 10.6052/0459-1879-2010-1-2009-028
    [7]Z. G. Yao. Bifurcation, chaotic dynamics and control of piezoelectric laminated composite beam[J]. Chinese Journal of Theoretical and Applied Mechanics, 2009, 41(1): 129-140. DOI: 10.6052/0459-1879-2009-1-2008-250
    [8]Three-dimensional progressive damage analysis of composite laminates containing a hole subjected to tensile loading[J]. Chinese Journal of Theoretical and Applied Mechanics, 2005, 37(6): 788-795. DOI: 10.6052/0459-1879-2005-6-2004-393
    [9]Periodic and chaotic oscillation of a parametrically excited viscoelastic moving belt with 1:3 internal resonance[J]. Chinese Journal of Theoretical and Applied Mechanics, 2004, 36(4): 443-454. DOI: 10.6052/0459-1879-2004-4-2003-369
    [10]THE INHERENT VIBRATION CHARACTERISTICS OF COMPOSITE LAMINATED BEAMS AND ELASTIC BEAMS 1)[J]. Chinese Journal of Theoretical and Applied Mechanics, 1998, 30(5): 628-634. DOI: 10.6052/0459-1879-1998-5-1995-170

Catalog

    Article Metrics

    Article views (746) PDF downloads (138) Cited by()
    Related

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return